全自動攪拌車的常見問題及應對方法
攪拌車、隨車吊、粉粒物料運輸車等等都屬于專用車，在建筑工程上使用較多，其中一些大型建筑所使用的混凝土大都是攪拌車運輸來的，攪拌車使用時間長了也會出現一些問題，下面全自動攪拌車廠家為您講幾個問題點。
Mixer truck, truck mounted crane, powder material transport truck, etc. are all special vehicles, which are widely used in construction projects. Most of the concrete used in some large-scale buildings is transported by mixer truck, and some problems will occur when the mixer truck is used for a long time. The following fully automatic mixer truck manufacturer will tell you some problems.
1.攪拌車漏出不明液體，有時候會發現，在攪拌車的底下有不明液體漏出，冷卻液的液面有所下降，這種問題的根源可能是連接冷卻液和攪拌車發動機間的橡皮管有裂縫。
1. Unknown liquid leaks from the mixer truck. Sometimes, it is found that unknown liquid leaks from the bottom of the mixer truck and the liquid level of the coolant drops. The root of this problem may be the crack in the rubber pipe connecting the coolant and the engine of the mixer truck.
保養方法：更換油裂縫的橡膠管，平時多觀察冷卻液，發現變質要及時更換，因為如果冷卻液變質，它的防銹品質會下降，不但容易導致散熱器、管路、軟管等部件的損壞，而且因冷卻液的主要成分是乙二醇，滴漏到地面上會造成環境污染，因此一定要注意。
Maintenance method: replace the rubber pipe with oil cracks. Observe the coolant frequently and replace it in time if it is found to be deteriorated. If the coolant is deteriorated, its rust prevention quality will decline, which will not only easily cause damage to radiator, pipeline, hose and other components, but also cause environmental pollution due to the main component of the coolant is ethylene glycol. Therefore, attention must be paid to it.
2.全自動攪拌車點不著火，要知道攪拌車的發動機啟動是靠電瓶的電流推動活塞點火完成的，所以啟動系統出現問題，很可能是由于電瓶生銹或者電瓶滴漏造成的。
2. The full-automatic mixer truck does not ignite. It should be known that the engine of the mixer truck is started by the piston driven by the current of the battery. Therefore, the problem of the starting system may be caused by the rust of the battery or the leakage of the battery.
保養方法：每隔一兩個月檢查一次電瓶液是否充足，如果不足，及時的添加蒸餾水適當高度，現在大部分攪拌車的電瓶都是免維護電瓶，所以不能擅自加水，此外每年都要檢查一下電瓶的正負端接點有無生銹或者污濁現象，如果有，要及時的清理干凈，以保持電路的暢通，電瓶修復后可延緩電瓶的報廢時間，減少資源浪費和廢棄電瓶對環境的污染。
Maintenance method: check whether the battery liquid is sufficient every two months. If it is insufficient, add distilled water to an appropriate height in time. Now most of the batteries of the mixer truck are maintenance free batteries, so it is not allowed to add water without authorization. In addition, check whether the positive and negative terminals of the batteries are rusted or dirty every year. If so, clean them in time to keep the circuit unblocked, After the battery is repaired, the scrapping time of the battery can be delayed, and the waste of resources and the pollution of the waste battery to the environment can be reduced.
3.攪拌車發動機排氣噪音增加，廢氣排放也超標，攪拌車的發動機廢氣經高溫發生煙花作用，很可能會導致排氣系統泄漏。
3. The exhaust noise of the engine of the mixer truck increases, and the exhaust gas emission also exceeds the standard. The engine exhaust gas of the mixer truck will cause fireworks after high temperature, which is likely to cause leakage of the exhaust system.
保養辦法：檢查排氣系統的管路、接口處是否被廢氣腐蝕，接口墊有沒有被沖壞，如果發現排氣系統泄漏一定要及時的修理或者更換，每年都要對排氣系統做一次檢查，保證其正常的使用。
Maintenance method: check whether the pipeline and interface of the exhaust system are corroded by exhaust gas and whether the interface pad is damaged. If the exhaust system is found to be leaking, it must be repaired or replaced in time. The exhaust system must be inspected once a year to ensure its normal use.
此外攪拌車的油耗增加，油耗增加常見的原因是輪胎的胎壓，輪胎的胎壓不足會導致行駛阻力增加，進而導致油耗增加，還會降低輪胎的使用壽命。要讓攪拌車的輪胎胎壓保持正常的范圍。更多相關問題就來我們網站http://www.zvmc.cn咨詢吧！
In addition, the fuel consumption of the mixer truck increases. The common reason for the increase in fuel consumption is the tire pressure. Insufficient tire pressure will lead to increased driving resistance, which will lead to increased fuel consumption and reduce the service life of the tire. Keep the tire pressure of the mixer truck within the normal range. Come to our website for more related questions http://www.zvmc.cn Consult!
