購買攪拌車之后一定先做這些事情！
1、新車開始使用時，須進行檢查和試車，正常時，方可正式使用。
1. When the new car is put into use, it must be comprehensively inspected and tested. It can be officially used only when it is normal.
2、輸送混凝土的容量，質量及塌落度應符合規定。
2. The capacity, quality and slump of transported concrete shall meet the regulations.
3、攪拌車在露天場地停放時，裝料前應先將攪拌筒反轉，把筒內的積水（或雨水）和雜物卸出，以保證運送混凝土的質量。
3. When the mixer truck is parked in the open field, the mixing drum shall be reversed before loading, and the ponding (or rainwater) and sundries in the drum shall be unloaded to ensure the quality of concrete transportation.
4、在出料斗、卸料溜槽旁工作時，要配帶防護用品。不要接近料斗及攪拌口,也不要向內窺看,更不得用手去摸旋轉的攪拌筒。
4. When working near the discharge hopper and discharge chute, wear protective articles. Do not approach the hopper and mixing port, do not look inward, and do not touch the rotating mixing drum with your hand.
5、在公路上行駛時，加長溜槽須翻轉放置在卸料溜槽上用掛鉤掛牢，再轉與車身垂直部位，用鎖緊裝置把卸料溜槽和加長溜槽鎖緊在機架上，防止由于不固定而搖動，造成傷人事故和影響其它車輛運行。
5. When driving on the highway, the extended chute shall be turned over and placed on the unloading chute, hung firmly with a hook, and then turned to the position perpendicular to the vehicle body. The unloading chute and the extended chute shall be locked on the frame with a locking device to prevent shaking due to instability, causing personal injury accidents and affecting the operation of other vehicles.
6、車穿越橋、洞、庫等設施時，須注意通過高度的尺寸及路面承受重量以免損壞攪拌車。
6. When the truck passes through bridges, holes, warehouses and other facilities, pay attention to the size of passing height and the weight borne by the road surface to avoid damaging the mixer truck.
7、工作裝置連續運轉時間不應超過8h。
7. The continuous operation time of the working device shall not exceed 8h.
8、交貨時，如發現水分蒸發，塌落度偏低不能滿足用戶要求時，可適當向筒內加水，然后以12—14r/min的速度旋轉30轉后卸料。
8. During delivery, if it is found that the water evaporates and the slump is too low to meet the user's requirements, add water to the cylinder appropriately, and then rotate for 30 revolutions at the speed of 12-14r / min before unloading.
9、攪拌車在空載運行及運送混凝土過程中，攪拌筒不得停止轉動以免滾道、滾輪局部碰損或混凝土產生離析現象。
9. During the no-load operation and concrete transportation of the mixer truck, the mixing drum shall not stop rotating, so as to avoid local collision damage of the raceway and roller or segregation of the concrete.
10、水箱的水量要經常加滿，以備急用。
10. The water tank should always be filled up for emergency use.
11、水箱加水前，須打開放氣閥把箱內空氣放掉，充氣供水后須及時關閉貯氣筒。
11. Before adding water to the water tank, the vent valve must be opened to release the air in the tank. After inflating and supplying water, the air reservoir must be closed in time.
注意：水箱僅在供水時加壓,不要帶著加壓水箱在公路上行駛
Note: the water tank is pressurized only when supplying water. Do not drive on the road with the pressurized water tank
以上就是小編為您提供的關于自上料攪拌車廠家 的知識，更多的精彩內容請您繼續關注我們的網站：http://www.zvmc.cn，我們會有更多對的精彩內容 為您分享.
The above is the knowledge about the manufacturer of self loading mixer truck provided by Xiaobian. Please continue to pay attention to our website for more wonderful contents: http://www.zvmc.cn , we will have more wonderful content for you to share
下一篇：小型混凝土攪拌車在工作時要注意容量？上一篇：檢查攪拌車磨損你有哪些技巧？
